Product ID:E-58D EMULSIFIER
MSDS Date:01/01/1997
FSC:6850
NIIN:01-263-8231
Kit Part:Y
MSDS Number: BMSSG

Emergency Phone: (310)450-1111

Info Phone: 213-450-1111

Cage: 98733

Telephone: 310-450-1111/FAX 310452-4046

Cage: 98733

ETHYLENE GLYCOL (SARA 313) (CERCLA)

CAS: 107-21-1

RTECS: KW2975000

ACGIH TLV: 50 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SLIGHT IRRITATION TO EYES AND SKIN.
MODERATE SINGLE ORAL DOSE TOXOCITY. INHALATION CAN CAUSE CONTROL
NERVOUS SYSTEM DEPRESSION.
Effects of Overexposure:SKIN OR EYE IRRITATION, DRUNKENNESS, NARCOSIS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN OR EYE DISORDER.

First Aid:FLUSH EYE OR SKIN WITH WATER. IF SWALLOWED INDUCE VOMITING,
CALL PHYSICIAN. REMOVE TO FRESH AIR, CALL PHYSICIAN.

Flash Point Method:PMCC
Flash Point:=111.1C, 232.F
Lower Limits:3.2
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CARBON DIOXIDE, DRY
CHEMICAL.
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:FLUSH WITH WATER, SOAK UP WITH ABSORBENT
MATERIAL, PLACE IN SEALED CONTAINERS. LARGE SPILL: DIKE AND PUMP
INTO DRUMS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP IN SEALED CONTAINERS AND AWAY
FROM HEAT AND OPEN FLAMES. DO NOT RE-USE CONTAINER FOR ANY PURPOSE
UNTIL COMMERCIALLY CLEANED. WASH BEFORE EATING, DRINKING OR USING
TOILET. AVOID EYE AND SKIN CON TACT.
Other Precautions:EMPTY CONTAINERS MAY CONTAIN VAPORS OR RESIDUES.

Respiratory Protection:APPROVED ORGANIC TYPE RESPIRATOR IN ABSENCE OF
PROPER ENVIRONMENTAL CONTROL.
Ventilation:LOCAL AND MECHANICAL(GENERAL) EXHAUST TO MAINTAIN TLV.
Protective Gloves:CHEMICAL RESISTANT
Eye Protection:SAFETY GLASSES.
Other Protective Equipment:CHEMICAL RESISTANT APRON.
Work Hygienic Practices:AVOID EYE AND SKIN CONTACT. WASH AFTER USING.
Supplemental Safety and Health
ITEM IS A 2 PART KIT. KIT CONTAINS 5 GAL CAN PENETRANT AND 5 GAL CAN
EMULSIFIER. EMULSIFIER REQUIRES DILUTION BEFORE USE.

HCC:N1
Boiling Pt:=193.3C, 380.F
Vapor Pres:ABOUT 1.2 MM
Vapor Density:VERY LOW
Spec Gravity:ABOUT 1.2
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT REDDISH PINK LIQUID, PRACTICALLY ODORLESS.

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL.
Stability Condition to Avoid:WILL IGNITE IN AIR AT ABOUT 775F.
Hazardous Decomposition Products:CARBON MONOXIDE.
Conditions to Avoid Polymerization:EXPOSURE TO OXIDANTS.

Waste Disposal Methods:CAN BE BURNED IF ALLOWED LOCALLY. OTHERWISE
DISPOSE IN ACCORDANCE WITH STATE AND FEDERAL LAWS.

SARA Title III Information:THIS PRODUCT CONTAINS THE FOLLOWING TOXIC
CHEMICAL(S) SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
THE EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986 AND
OF 40 CFR 372: 107-21-1 , ETHYLENE GLYCOL.
State Regulatory Information:CALIFORNIA PROPOSITION 65 NOTICE-
DETECTABLE AMOUNTS OF SOME CHEMICALS KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE BIRTH DEFECTS, OR OTHER REPRODUCTIVE HARM MAY
BE FOUND IN VARIOUS PRODUCTS YOU PURCHASE FROM MET-L-CHEK, IN
THEIR VAPORS OR MAY RESULT FROM THEIR USE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.